If this is your first visit, be sure to check out the FAQ by clicking the link above. You may have to register before you can post: click the register link above to proceed. To start viewing messages, select the forum that you want to visit from the selection below. |
|
|
Thread Tools | Display Modes |
#1
|
|||
|
|||
Dodge Caravan 2002 Transmission Problem
Hi all,
I have a 2002 Dodge Caravan automatic transmission, currently with 80K miles (mostly highway). Since about 20K miles I started feeling some "bang" noise down shifting to second gear. The dealer says all is OK. They replaced pump, changed computer settings and flushed computer software but nothing helps. When I asked them to hookup that computer thing that logs events they found every excuse in the world not to do so. The problem is getting worse (and the warranty will expire soon) any ideas (on top of going to another transmission place)? Thank You |
Ads |
#2
|
|||
|
|||
Dodge Caravan 2002 Transmission Problem
"Stam" > wrote in message m... > Hi all, > I have a 2002 Dodge Caravan automatic transmission, currently with 80K miles > (mostly highway). > Since about 20K miles I started feeling some "bang" noise down shifting to > second gear. > The dealer says all is OK. They replaced pump, changed computer settings and > flushed computer software but nothing helps. When I asked them to hookup > that computer thing that logs events they found every excuse in the world > not to do so. > The problem is getting worse (and the warranty will expire soon) any ideas > (on top of going to another transmission place)? > > Thank You Dodge has had a lot of transmission problems over the past decade, but I thought that most of them had been ironed out by 2002. Maybe not The Caravan in particular was a problematic model because a lot of the smaller RE variant transmissions were used, and they just did not hold up well at all. Some say that the use of nonconforming transmission fluid caused a lot of the problems. Special fluids are available and must be used. In addition, Chrysler made a lot of changes to try to toughen up this series. A little later they introduced the 545RFE transmission (in about 2000?). I haven't kept up with them but they were believed to be much more durable and reliable. I wouldn't let the warranty expire before I got this solved. It could get expensive. |
#3
|
|||
|
|||
Dodge Caravan 2002 Transmission Problem
Stam wrote: > I have a 2002 Dodge Caravan automatic transmission, currently > with 80K miles mostly highway). Since about 20K miles I > started feeling some "bang" noise down shifting to second gear. > The dealer says all is OK. They replaced pump, changed computer > settings and flushed computer software but nothing helps. When > I asked them to hookup that computer thing that logs events > they found every excuse in the world not to do so. Considering the cost of a new transmission, I would insist on having the computer hooked up, even if I had to pay for it or go to another dealer. And I would want a printout or at least something in writing detailing the log. Have you tried another dealer? I've learned that the one that sells the vehicle is not necessarily the one that will provide the best service, even during the warranty period (in AZ, Sanderson Ford - lousy. Sunset Ford - great). I would file a complaint with www.bbb.org and, if the dealer is AAA approved, with AAA (provides binding arbitration that has real teeth, binding only on the garage, not the customer, whether you're an AAA member or not). Have you asked in some brand-specific forums, such as www.dodgetalk.com, www.dodgeforum.com, www.chryslerforum.com, or www.chrysler-forum.com? |
#4
|
|||
|
|||
Dodge Caravan 2002 Transmission Problem
|
#6
|
|||
|
|||
Dodge Caravan 2002 Transmission Problem
On Fri, 21 Oct 2005, larry moe 'n curly wrote:
> Consumer Reports says the problem rate for transmissions is: > > _______Chrysler minivans_________average vehicle_______ > > 2004:_____very low__________________very low > 2003:_____low_______________________very low > 2002:_____average___________________low > 2001:_____low_______________________low > 2000:_____very high_________________low > 1999:_____very high_________________low > 1998:_____high______________________low > 1997:_____high______________________average This asinine chart, together with basic knowledge of what transmissions were used in Chrysler minivans in which model years, does a splendid job of telling us all we need to know about the veracity of Condemner Retards' "research". |
#7
|
|||
|
|||
Dodge Caravan 2002 Transmission Problem
On Fri, 21 Oct 2005 17:32:56 GMT, "Stam" > wrote:
>Hi all, >I have a 2002 Dodge Caravan automatic transmission, currently with 80K miles >(mostly highway). >Since about 20K miles I started feeling some "bang" noise down shifting to >second gear. >The dealer says all is OK. They replaced pump, changed computer settings and >flushed computer software but nothing helps. When I asked them to hookup >that computer thing that logs events they found every excuse in the world >not to do so. >The problem is getting worse (and the warranty will expire soon) any ideas >(on top of going to another transmission place)? > >Thank You > > Direct their attention to Service Bulletin number 21-004-05, which describes your problem and the fix. If they replaced the front pump (part of this bulletin's instructions), I'm surprised they didn't connect to the powertrain module and read fault codes. Part of the repair is to verify that the controller is at the latest software revision level. If they really did as you say, it should be OK. Keep hounding them until they fix it. The bulletin specifically says this is covered under warranty. |
#8
|
|||
|
|||
Dodge Caravan 2002 Transmission Problem
Daniel J. Stern wrote: > On Fri, 21 Oct 2005, larry moe 'n curly wrote: > > > Consumer Reports says the problem rate for transmissions is: > > > > _______Chrysler minivans_________average vehicle_______ > > > > 2004:_____very low__________________very low > > 2003:_____low_______________________very low > > 2002:_____average___________________low > > 2001:_____low_______________________low > > 2000:_____very high_________________low > > 1999:_____very high_________________low > > 1998:_____high______________________low > > 1997:_____high______________________average > > This asinine chart, together with basic knowledge of what transmissions > were used in Chrysler minivans in which model years, does a splendid job > of telling us all we need to know about the veracity of Condemner Retards' > "research". Then where are we supposed to get our information, from friends and mechanics who still believe that Chevys and Fords are great and "Jap stuff" is junk? Those of us who aren't experts or industry insiders have very few other sources of reliability information, but it seems that CR's overall reliability scores coincide well with Popular Mechanics' and the records that one large fleet leasing company keeps. CR reliability surveys do seem to get it right for digital cameras, TVs, and central air conditioners (A/C experts seem to agree except for York, which they hold in higher regard), so why should they be so wrong about cars? |
#9
|
|||
|
|||
Dodge Caravan 2002 Transmission Problem
Daniel J. Stern wrote: > This asinine chart, together with basic knowledge of what transmissions > were used in Chrysler minivans in which model years, does a splendid job > of telling us all we need to know about the veracity of Condemner Retards' > "research". So why did Chrysler respec the fluid 3-4 times since introducing their 1st 4-spd auto? Was it because they had no breakdown problems? |
#10
|
|||
|
|||
Dodge Caravan 2002 Transmission Problem
On Sun, 23 Oct 2005, MaceFace wrote:
>> This asinine chart, together with basic knowledge of what transmissions >> were used in Chrysler minivans in which model years, does a splendid >> job of telling us all we need to know about the veracity of Condemner >> Retards' "research". > > So why did Chrysler respec the fluid 3-4 times since introducing their > 1st 4-spd auto? Was it because they had no breakdown problems? The question is a complete nonsequitur. Are you still interested in the answer? |
Thread Tools | |
Display Modes | |
|
|
Similar Threads | ||||
Thread | Thread Starter | Forum | Replies | Last Post |
2002 dodge caravan sport has intermintant dash gage and speedometer problem | burtis | Dodge | 1 | July 2nd 05 12:01 AM |
Power Windows Problem on 2000 Dodge Caravan | [email protected] | Chrysler | 5 | June 2nd 05 05:31 AM |
!990 Dodge Caravan Flooding problem | Daniel J. Stern | Chrysler | 2 | May 17th 05 07:44 PM |
New *FREE* Corvette Discussion Forum | JLA ENTERPRISES TECHNOLOGIES INTEGRATION | Corvette | 12 | November 30th 04 06:36 PM |