If this is your first visit, be sure to check out the FAQ by clicking the link above. You may have to register before you can post: click the register link above to proceed. To start viewing messages, select the forum that you want to visit from the selection below. |
|
|
Thread Tools | Display Modes |
#1
|
|||
|
|||
Cant shift to 4x4 drive
I have a 92 jeep wrangler and am not able to shift it into four wheel drive.
The linkage is all good and it shifts good. Also the 4x4 light is always on even when not in four. So i looked at the senor and took off the cover where the fork and the bearing cupler is (THe spot where u can see 4 wheel drive locking in) I can move the couple over by hand and 4 wheel drive will work then but so i was thinking that the fork wont move it over by its selve. I looked at all the vacuum hoses and I bought a new Vacuum diaphram thinking it was just low vacuum but that didnt help either. -- Message posted via CarKB.com http://www.carkb.com/Uwe/Forums.aspx/jeep-cars/200601/1 |
Ads |
#2
|
|||
|
|||
Cant shift to 4x4 drive
You describe a common problem on YJ's. Did you also check the vacuum line
going to the transfer case? http://www.4x4wire.com/forums/showfl...60&Main=828553 http://www.jeeptech.com/axle/d30.html -- JimG 80' CJ-7 258 CID, HEI 4.56 Gears, Lock-Right F&R 35" BFG MT on 15x10 Centerlines D44 Rear, D30 Front. SOA Dana 300 w/4:1 & Currie twin sticks Warn X8000i w/ dual batteries 00' TJ Sport 4.0L, 5sp 4.56 Gears, TrueTrac rear 33" BFG AT on 15x8 Eagle Alloys D35 Rear, D30 Front. 3" Suspension Lift "Jeff via CarKB.com" wrote in message ... >I have a 92 jeep wrangler and am not able to shift it into four wheel >drive. > The linkage is all good and it shifts good. Also the 4x4 light is always > on > even when not in four. So i looked at the senor and took off the cover > where > the fork and the bearing cupler is (THe spot where u can see 4 wheel drive > locking in) I can move the couple over by hand and 4 wheel drive will work > then but so i was thinking that the fork wont move it over by its selve. I > looked at all the vacuum hoses and I bought a new Vacuum diaphram thinking > it > was just low vacuum but that didnt help either. > > -- > Message posted via CarKB.com > http://www.carkb.com/Uwe/Forums.aspx/jeep-cars/200601/1 |
#3
|
|||
|
|||
Cant shift to 4x4 drive
I had a trail buddy with a CJ7 that used to think it was funny to pull off
the vacume line that attached to the diaphram on the front axle of my YJ when I wasn't looking. It never failed, he always waited until right before we hit a steep incline. Scott 91YJ "JimG" > wrote in message ... > You describe a common problem on YJ's. Did you also check the vacuum line > going to the transfer case? > > http://www.4x4wire.com/forums/showfl...60&Main=828553 > http://www.jeeptech.com/axle/d30.html > > -- > JimG > 80' CJ-7 258 CID, HEI > 4.56 Gears, Lock-Right F&R > 35" BFG MT on 15x10 Centerlines > D44 Rear, D30 Front. SOA > Dana 300 w/4:1 & Currie twin sticks > Warn X8000i w/ dual batteries > > 00' TJ Sport 4.0L, 5sp > 4.56 Gears, TrueTrac rear > 33" BFG AT on 15x8 Eagle Alloys > D35 Rear, D30 Front. 3" Suspension Lift > > "Jeff via CarKB.com" wrote in message ... >>I have a 92 jeep wrangler and am not able to shift it into four wheel >>drive. >> The linkage is all good and it shifts good. Also the 4x4 light is always >> on >> even when not in four. So i looked at the senor and took off the cover >> where >> the fork and the bearing cupler is (THe spot where u can see 4 wheel >> drive >> locking in) I can move the couple over by hand and 4 wheel drive will >> work >> then but so i was thinking that the fork wont move it over by its selve. >> I >> looked at all the vacuum hoses and I bought a new Vacuum diaphram >> thinking it >> was just low vacuum but that didnt help either. >> >> -- >> Message posted via CarKB.com >> http://www.carkb.com/Uwe/Forums.aspx/jeep-cars/200601/1 > > |
#4
|
|||
|
|||
Cant shift to 4x4 drive
I am thinking you are talking about the front axle disconnect?
That would mean you need to open it back up and apply vacuum direct to the shift motor to see if the fork moves. It is possible the diaphragm is torn inside the unit. Mike 86/00 CJ7 Laredo, 33x9.5 BFG Muds, 'glass nose to tail in '00 88 Cherokee 235 BFG AT's Canadian Off Road Trips Photos: Non members can still view! Jan/06 http://www.imagestation.com/album/pi...?id=2115147590 (More Off Road album links at bottom of the view page) "Jeff via CarKB.com" wrote: > > I have a 92 jeep wrangler and am not able to shift it into four wheel drive. > The linkage is all good and it shifts good. Also the 4x4 light is always on > even when not in four. So i looked at the senor and took off the cover where > the fork and the bearing cupler is (THe spot where u can see 4 wheel drive > locking in) I can move the couple over by hand and 4 wheel drive will work > then but so i was thinking that the fork wont move it over by its selve. I > looked at all the vacuum hoses and I bought a new Vacuum diaphram thinking it > was just low vacuum but that didnt help either. > > -- > Message posted via CarKB.com > http://www.carkb.com/Uwe/Forums.aspx/jeep-cars/200601/1 |
#5
|
|||
|
|||
Cant shift to 4x4 drive
Watch your friends, and your enemies will never bother you.
God Bless America, Bill O|||||||O http://www.billhughes.com/ reconair wrote: > > I had a trail buddy with a CJ7 that used to think it was funny to pull off > the vacume line that attached to the diaphram on the front axle of my YJ > when I wasn't looking. It never failed, he always waited until right before > we hit a steep incline. > > Scott > 91YJ |
Thread Tools | |
Display Modes | |
|
|
Similar Threads | ||||
Thread | Thread Starter | Forum | Replies | Last Post |
Q re 95 cabrio shift relay lever | Walter Harley | VW water cooled | 1 | September 1st 05 06:54 PM |
(2) 88 accord DX shift lever locked in ' park' prob......UPDATE. | bottledoctor | Honda | 0 | August 15th 05 06:27 PM |
Shift Kits - What are they all about? | .boB | Ford Mustang | 1 | February 14th 05 04:32 AM |
Vibrations when i'm standing still on my A4 from 2000 when it is in 'drive' | Eykens Kenny | Audi | 2 | July 15th 04 05:42 AM |