If this is your first visit, be sure to check out the FAQ by clicking the link above. You may have to register before you can post: click the register link above to proceed. To start viewing messages, select the forum that you want to visit from the selection below. |
|
|
Thread Tools | Display Modes |
#1
|
|||
|
|||
P0421 code after O2 replacement
A short while ago I replaced the front O2 sensor
after a CEL showed it was bad. Now (a couple gas tanks later) I'm getting P0421, indicating the front (pre-heat) cat has gone bad. Probably the failing O2 affected the cat, which has 150K miles. But I'm wondering if this code could be triggered by a failing 2nd O2 sensor, the one behind the pre-cat. Does the P0421 usually just mean replace the cat? thanks, -- John F. Detke | "Where dat mommy go?" | -- James, age 2 when his mom Felton, CA | slipped away for 2 minutes peace |
Ads |
#2
|
|||
|
|||
P0421 code after O2 replacement
Remember that the cat is only warrenited for 80,000, so, from the mfrs
standpoint, it should fail at about 100,000 so that you buy a new one, or trade/sell the car. In other words, the cat may actually be bad. Remember that aftermarket midpipes with cat are less expensive than the factory part. (I'm not saying that they are CARB approved) "John Detke" > wrote in message ... > A short while ago I replaced the front O2 sensor > after a CEL showed it was bad. Now (a couple > gas tanks later) I'm getting P0421, indicating > the front (pre-heat) cat has gone bad. Probably > the failing O2 affected the cat, which has 150K > miles. But I'm wondering if this code could > be triggered by a failing 2nd O2 sensor, the one > behind the pre-cat. > > Does the P0421 usually just mean replace the cat? > > > thanks, > -- > John F. Detke | "Where dat mommy go?" > | -- James, age 2 when his mom > Felton, CA | slipped away for 2 minutes peace > > > |
#3
|
|||
|
|||
P0421 code after O2 replacement
> GUEST wrote: > A short while ago I replaced the front O2 sensor > after a CEL showed it was bad. Now (a couple > gas tanks later) I'm getting P0421, indicating > the front (pre-heat) cat has gone bad. Probably > the failing O2 affected the cat, which has 150K > miles. But I'm wondering if this code could > be triggered by a failing 2nd O2 sensor, the one > behind the pre-cat. > > Does the P0421 usually just mean replace the cat? > > > thanks, > -- > John F. Detke | "Where dat mommy go?" > | -- James, age 2 when his mom > Felton, CA | slipped away for 2 minutes peace On my A6 Avant, I have been getting these same codes since at least 80K in 2004. P0421 (Pri Cat Bank 1), P0431 (Pri Cat Bank 2), and P1423 (secondary air flow too low bank 1) always show up 1 or 2 days after being cleared. I can guarandamtee you these cats did not go bad at 80K. How to know? I always knew those emissions tests in Denver would be good for something. In 2004 at 66K, my hydrocarbons were 0.07 gm/mi and NOx was 0.2 gm/mi. In 2006, at 136K HC were 0.13 gm/mi an NOx 0.3 gm/mi. Pass/fail cutpoints are 1.2 for HC and 3.0 for NOx. This car is pretty darn clean from an emissions standpoint. If the cat was shot, HC would be much higher, trust me, people I know who have had bad cats have failed the emissions test hands down. Even if my cat is bad, why would I replace it if my car runs that clean? That makes no sense. I need another emissions test this year (177K) so will do that before taking to my mechanic this week. I will try to have him do a pre- post- cat temperature reading. The fuel economy on this car has always ranged from 20-22 mpg, so I don't believe it is an O2 sensor. I believe it is a secondary air leak issue that is of very minor concern (except for that damn CEL/MIL :x ). Hope to have a diagnostic on that this week. Will let you know what transpires..... |
#4
|
|||
|
|||
P0421 code after O2 replacement
If you have a california style cat system-- the front cat does have a
history of high failure rates. That aside, the 99 manual lists these possible causes for the P0421 code in the following order. Warm Up Cat exhaust system leak Front O2 sensor Rear O2 Sensor Mass air flow sensor Throttle position sensor Vehicle Speed sensor. The process of elimination in the manual involves use of Mazda dealer specific equipment. The presence or absence of other codes may help eliminate some of the posibilities, as should normal indications of the speedometer, etc. Not a few have changed out the calif spec exhaust system to federal spec, eliminating the warmup cat. "greggthomas" > wrote in message ... > > > GUEST wrote: > > A short while ago I replaced the front O2 sensor > > after a CEL showed it was bad. Now (a couple > > gas tanks later) I'm getting P0421, indicating > > the front (pre-heat) cat has gone bad. Probably > > the failing O2 affected the cat, which has 150K > > miles. But I'm wondering if this code could > > be triggered by a failing 2nd O2 sensor, the one > > behind the pre-cat. > > > > Does the P0421 usually just mean replace the cat? > > > > > > thanks, > > -- > > John F. Detke | "Where dat mommy go?" > > | -- James, age 2 when his mom > > Felton, CA | slipped away for 2 minutes peace > > On my A6 > Avant, I have been getting these same codes since at least 80K in > 2004. P0421 (Pri Cat Bank 1), P0431 (Pri Cat Bank 2), and P1423 > (secondary air flow too low bank 1) always show up 1 or 2 days after > being cleared. > > I can guarandamtee you these cats did not go bad at 80K. > > How to know? I always knew those emissions tests in Denver would be > good for something. In 2004 at 66K, my hydrocarbons were 0.07 gm/mi > and NOx was 0.2 gm/mi. In 2006, at 136K HC were 0.13 gm/mi an NOx 0.3 > gm/mi. Pass/fail cutpoints are 1.2 for HC and 3.0 for NOx. This car is > pretty darn clean from an emissions standpoint. > > If the cat was shot, HC would be much higher, trust me, people I know > who have had bad cats have failed the emissions test hands down. Even > if my cat is bad, why would I replace it if my car runs that clean? > That makes no sense. > > I need another emissions test this year (177K) so will do that before > taking to my mechanic this week. I will try to have him do a pre- > post- cat temperature reading. > > The fuel economy on this car has always ranged from 20-22 mpg, so I > don't believe it is an O2 sensor. I believe it is a secondary air > leak issue that is of very minor concern (except for that damn > CEL/MIL :x ). Hope to have a diagnostic on that this week. > > Will let you know what transpires..... > |
#5
|
|||
|
|||
P0421 code after O2 replacement
Is there any information on changing a California car to Federal spec on the
Internet, or does anyone sell a kit? I have a CA car with a bad warm-up cat (due to a couple of misfires caused by a bad coil) and I'm in AZ, so I'd rather simplify the system rather than install a part with a history of going bad on people. Or, does anyone know of an aftermarket warm-up cat? Thanks for any info you can provide, Mark "Chuck" > wrote in message ... > If you have a california style cat system-- the front cat does have a > history of high failure rates. > > That aside, the 99 manual lists these possible causes for the P0421 code > in > the following order. > Warm Up Cat > exhaust system leak > Front O2 sensor > Rear O2 Sensor > Mass air flow sensor > Throttle position sensor > Vehicle Speed sensor. > The process of elimination in the manual involves use of Mazda dealer > specific equipment. > The presence or absence of other codes may help eliminate some of the > posibilities, as should normal > indications of the speedometer, etc. > Not a few have changed out the calif spec exhaust system to federal spec, > eliminating the warmup cat. > > > "greggthomas" > wrote in > message > ... >> >> > GUEST wrote: >> > A short while ago I replaced the front O2 sensor >> > after a CEL showed it was bad. Now (a couple >> > gas tanks later) I'm getting P0421, indicating >> > the front (pre-heat) cat has gone bad. Probably >> > the failing O2 affected the cat, which has 150K >> > miles. But I'm wondering if this code could >> > be triggered by a failing 2nd O2 sensor, the one >> > behind the pre-cat. >> > >> > Does the P0421 usually just mean replace the cat? >> > >> > >> > thanks, >> > -- >> > John F. Detke | "Where dat mommy go?" >> > | -- James, age 2 when his mom >> > Felton, CA | slipped away for 2 minutes peace >> >> On my A6 >> Avant, I have been getting these same codes since at least 80K in >> 2004. P0421 (Pri Cat Bank 1), P0431 (Pri Cat Bank 2), and P1423 >> (secondary air flow too low bank 1) always show up 1 or 2 days after >> being cleared. >> >> I can guarandamtee you these cats did not go bad at 80K. >> >> How to know? I always knew those emissions tests in Denver would be >> good for something. In 2004 at 66K, my hydrocarbons were 0.07 gm/mi >> and NOx was 0.2 gm/mi. In 2006, at 136K HC were 0.13 gm/mi an NOx 0.3 >> gm/mi. Pass/fail cutpoints are 1.2 for HC and 3.0 for NOx. This car is >> pretty darn clean from an emissions standpoint. >> >> If the cat was shot, HC would be much higher, trust me, people I know >> who have had bad cats have failed the emissions test hands down. Even >> if my cat is bad, why would I replace it if my car runs that clean? >> That makes no sense. >> >> I need another emissions test this year (177K) so will do that before >> taking to my mechanic this week. I will try to have him do a pre- >> post- cat temperature reading. >> >> The fuel economy on this car has always ranged from 20-22 mpg, so I >> don't believe it is an O2 sensor. I believe it is a secondary air >> leak issue that is of very minor concern (except for that damn >> CEL/MIL :x ). Hope to have a diagnostic on that this week. >> >> Will let you know what transpires..... >> > > |
Thread Tools | |
Display Modes | |
|
|
Similar Threads | ||||
Thread | Thread Starter | Forum | Replies | Last Post |
2003 VW GTI - OBDII Code P0421 | [email protected] | VW water cooled | 2 | December 6th 06 01:35 PM |
OBDII Code P0421 - 2003 VW GTI - Please Help! | [email protected] | Technology | 1 | December 5th 06 09:48 PM |
Need help code ERROR p0171 or code [51 in the haynes repair manual] | pchotspot | Dodge | 2 | September 30th 06 01:40 PM |
first dead battery, now no radio. code ? what code ? | Scott | Audi | 12 | January 25th 05 04:07 PM |
**HELP** CODE 26 Transmission Code - Car Starts then Dies | paul | Saturn | 3 | July 18th 04 03:01 PM |