If this is your first visit, be sure to check out the FAQ by clicking the link above. You may have to register before you can post: click the register link above to proceed. To start viewing messages, select the forum that you want to visit from the selection below. |
|
|
Thread Tools | Display Modes |
#1
|
|||
|
|||
a6 ellectric window problem
i am having problems with my passenger window sometimes it works ok and then
sometimes it only comes part way up and shoots back down. to get the window fully up i have to do it gradually a couple of inches at a time but like i say sometimes its ok. i have took it back to the dealer twice now i checked it when i collected the car seemed to be ok but an hour later it was playing up again the garage said they have stripped it right down and put it back together i was wondering if anyone as any ideas what this might be before i ring the garage bak up on monday and get fobbed off cheers stef |
Ads |
#2
|
|||
|
|||
a6 ellectric window problem
On Fri, 13 Jan 2006 19:10:38 -0000, "Stef" >
wrote: >i am having problems with my passenger window sometimes it works ok and then >sometimes it only comes part way up and shoots back down. to get the window >fully up i have to do it gradually a couple of inches at a time but like i >say sometimes its ok. >i have took it back to the dealer twice now i checked it when i collected >the car seemed to be ok but an hour later it was playing up again the garage >said they have stripped it right down and put it back together i was >wondering if anyone as any ideas what this might be before i ring the >garage bak up on monday and get fobbed off >cheers >stef > Sure sounds like the window regulator is dying... |
#3
|
|||
|
|||
a6 ellectric window problem
Stef wrote: > i am having problems with my passenger window sometimes it works ok and then > sometimes it only comes part way up and shoots back down. to get the window > fully up i have to do it gradually a couple of inches at a time but like i > say sometimes its ok. > i have took it back to the dealer twice now i checked it when i collected > the car seemed to be ok but an hour later it was playing up again the garage > said they have stripped it right down and put it back together i was > wondering if anyone as any ideas what this might be before i ring the > garage bak up on monday and get fobbed off > cheers > stef Window Guide Replacement Vehicle worked on: 1999 Audi A6 2.8 quattro. http://www.audiworld.com/tech/int45.shtml (copy & paste in browser for full details) Disclaimer: This is a basic walkthrough of a repair I did. I am not a licensed mechanic. You may perform this at your own risk. I am not responsible for your mistakes and this is written as a reference guide only. Difficulty level: Not too difficult, only problems that should be encountered are alignment issues when reinstalling. About as hard as changing the spark plugs on the 30v V6. Basic problem: Window operates slowly, wants to halt and go back down, etc... Fix: Replace plastic window guides, lube rails. Cost: Approx $15.00, 1/2 hr work. Part no.: 4B0-837-463-B Tools: Phillips Screwdriver, Torx T15 and T45, allen wrench or small screwdriver. Procedu Pass/rear doors, drivers not tackled yet. 1. I started with the window down. 2. Remove 2 screws that hold door panel in, one in front jamb, one in rear. 3. Pop out the power window switch, there is a small hole in the underside of the door handle that you can put a small screwdriver or allen wrench in and pry from the front of the switch toward the rear of the car and pull up. 4. Disconnect window switch. 5. Pull door panel up and off. not too tough. 6. Disconnect 3 wires near front of panel, 2 for speakers, third for ?? didn't trace them out. 7. Put the door panel in a safe place. 8. Disconnect power lock harness, power mirror, heated mirror, power window harness. 9. Unclip the wiring from the door panel as much as possible. 10. Mark the 4 T-45 bolts and shims. (one in each corner) 11. Remove 4 bolts holding in the inner frame. They may be slightly different, if so make sure to note where each goes. 12. Pull straight up on the frame. the entire assembly comes out including the mirror and upper window/door frame. Then pull it out of the outer door skin. 13. Place the door frame so you can get to the back portion that is hidden when installed. 14. Use a T-15 to remove the 2 screws that hold the window in place. 15. Unclamp the plastic window holders and wiggle them out. Now you can pull your window down and out of the frame. 16. Finally you are ready to remove the components that are giving you trouble. I found it is easiest to have the window guides in the center of the track, so hook up your switch and put it halfway up. Then rotate the guide toward the outside of the track, then out. 17. Now flip it over and you will see how it attaches to the cable. Disconnect this and it is out. Repeat for other guide. 18. Lube the track and cable with some grease. I prefer White Lithium, it is waterproof and easy to clean up. 19. Install new guides by locking into cable then placing on outer edge of track and rotating into place. 20. Put the window guides back to the bottom, and install the glass. I put the glass in so it lined up as I took it out. Then put it all the way to the top to make sure it went into its proper area. 21. You can now reinstall the inner frame, making sure to use the proper bolts and shims. One has a larger washer on mine than the rest. 22. Reattach all wiring and test the window. 23. Reinstall door panel. |
Thread Tools | |
Display Modes | |
|
|
Similar Threads | ||||
Thread | Thread Starter | Forum | Replies | Last Post |
2003 Accord Radio Display Problem | Mike | Honda | 41 | July 13th 05 04:32 PM |
Chrysler power window problem | Ed | Dodge | 4 | April 17th 05 07:36 AM |
Dodge Caravan Window problem | ChinaCat | Dodge | 14 | October 3rd 04 10:53 PM |
Alfa 164 Electric Window problem | Emjay | Alfa Romeo | 2 | July 13th 04 12:42 AM |