If this is your first visit, be sure to check out the FAQ by clicking the link above. You may have to register before you can post: click the register link above to proceed. To start viewing messages, select the forum that you want to visit from the selection below. |
|
|
Thread Tools | Display Modes |
#1
|
|||
|
|||
low coolant
Hello,
I have a '96 Saturn with 120k on it. The coolant indicator light come on and goes off intermittently. I had an OBD read and it reported a problem stating something like "low coolant sensor". Is there a sensor that monitors coolant level? If so, where is it--I don't see anything in the overflow reservoir tub. This sensor obviously reports back to the computer. Could this sensor error prevent the drive-cycle from taking place. I disconnected my battery about 4 weeks/400mi ago and my computer is reporting no codes which is preventing me from getting an NYS (New York) inspection. By the way, the temp sensor is working fine and the car does not overheat. Thank you for your help, Rob |
Ads |
#2
|
|||
|
|||
low coolant
Rob,
You need to look closer. There is indeed a small sensor located in the bottom of the plastic coolant reservoir. If it comes on intermittently, then you are probably low on coolant and the solution is most likely to add a 50 mix to get you to the full cold line. It might also be a good time to flush and refill the system since this is supposed to be done every two years. If you do, then remove the coolant recovery reservoir and clean it thoroughly with hot soapy water. Make sure you also use the correct coolant (Saturn's use special coolant) and add the 2 crushed leak-stop pellets as well. The coolant and pellets are available from the dealer. Bob "Rob" > wrote in message ps.com... > Hello, > > I have a '96 Saturn with 120k on it. The coolant indicator light come > on and goes off intermittently. I had an OBD read and it reported a > problem stating something like "low coolant sensor". Is there a > sensor that monitors coolant level? If so, where is it--I don't see > anything in the overflow reservoir tub. This sensor obviously reports > back to the computer. Could this sensor error prevent the drive-cycle > from taking place. I disconnected my battery about 4 weeks/400mi ago > and my computer is reporting no codes which is preventing me from > getting an NYS (New York) inspection. > > By the way, the temp sensor is working fine and the car does not > overheat. > > Thank you for your help, > Rob > |
#3
|
|||
|
|||
low coolant
Thank you for the tip. You're are correct I didn't look that closely. I
plan to remove the reservoir tank and do a more thorough search. The level in the reservoir is fine, it reads properly for both the cold and hot levels. Flushing it also a good suggestion. Perhaps the sensor is bad or a dirty reservoir is preventing proper operation. Would this flaky sensor prevent a drive cycle from taking place, thus preventing the computer from generating codes. I disconnected the battery a while ago and the state's NYS inspection computer is telling my mechanic that there are no codes to report. He told me to drive the car for a while to get the computer to generate codes. I've driven the car for 4 wks/400miles and the computer is still in the same state. "Bob Shuman" > wrote in message . .. > Rob, > > You need to look closer. There is indeed a small sensor located in the > bottom of the plastic coolant reservoir. If it comes on intermittently, > then you are probably low on coolant and the solution is most likely to > add a 50 mix to get you to the full cold line. > > It might also be a good time to flush and refill the system since this is > supposed to be done every two years. If you do, then remove the coolant > recovery reservoir and clean it thoroughly with hot soapy water. Make > sure you also use the correct coolant (Saturn's use special coolant) and > add the 2 crushed leak-stop pellets as well. The coolant and pellets are > available from the dealer. > > Bob > > > "Rob" > wrote in message > ps.com... >> Hello, >> >> I have a '96 Saturn with 120k on it. The coolant indicator light come >> on and goes off intermittently. I had an OBD read and it reported a >> problem stating something like "low coolant sensor". Is there a >> sensor that monitors coolant level? If so, where is it--I don't see >> anything in the overflow reservoir tub. This sensor obviously reports >> back to the computer. Could this sensor error prevent the drive-cycle >> from taking place. I disconnected my battery about 4 weeks/400mi ago >> and my computer is reporting no codes which is preventing me from >> getting an NYS (New York) inspection. >> >> By the way, the temp sensor is working fine and the car does not >> overheat. >> >> Thank you for your help, >> Rob >> > > |
#4
|
|||
|
|||
low coolant
Bob Shuman wrote:
> Rob, > > You need to look closer. There is indeed a small sensor located in the > bottom of the plastic coolant reservoir. If it comes on intermittently, > then you are probably low on coolant and the solution is most likely to add > a 50 mix to get you to the full cold line. > > It might also be a good time to flush and refill the system since this is > supposed to be done every two years. If you do, then remove the coolant > recovery reservoir and clean it thoroughly with hot soapy water. Make sure > you also use the correct coolant (Saturn's use special coolant) and add the > 2 crushed leak-stop pellets as well. The coolant and pellets are available > from the dealer. > > Bob > > > "Rob" > wrote in message > ps.com... > >>Hello, >> >>I have a '96 Saturn with 120k on it. The coolant indicator light come >>on and goes off intermittently. I had an OBD read and it reported a >>problem stating something like "low coolant sensor". Is there a >>sensor that monitors coolant level? If so, where is it--I don't see >>anything in the overflow reservoir tub. This sensor obviously reports >>back to the computer. Could this sensor error prevent the drive-cycle >>from taking place. I disconnected my battery about 4 weeks/400mi ago >>and my computer is reporting no codes which is preventing me from >>getting an NYS (New York) inspection. >> >>By the way, the temp sensor is working fine and the car does not >>overheat. >> >>Thank you for your help, >>Rob >> > > > You should also check the wires going from the sensor all the way to the harness. When my Saturn started flashing the low coolant indicator it turned out to be that the sensor wires had been chewed up. I fixed it, and then it did it again. It appears that a small animal out here favors yellow wires. Now I park the Saturn in my garage. JM |
#5
|
|||
|
|||
low coolant
It is dependent on the number of ignition (starts) cycles. I think it
requires 40 or 50 cycles to turn off/reset that history flag. Good luck. Bob "Rob" > wrote in message ... > Thank you for the tip. You're are correct I didn't look that closely. I > plan to remove the reservoir tank and do a more thorough search. The > level in the reservoir is fine, it reads properly for both the cold and > hot levels. Flushing it also a good suggestion. Perhaps the sensor is > bad or a dirty reservoir is preventing proper operation. > > Would this flaky sensor prevent a drive cycle from taking place, thus > preventing the computer from generating codes. I disconnected the battery > a while ago and the state's NYS inspection computer is telling my mechanic > that there are no codes to report. He told me to drive the car for a > while to get the computer to generate codes. I've driven the car for 4 > wks/400miles and the computer is still in the same state. > > > > "Bob Shuman" > wrote in message > . .. >> Rob, >> >> You need to look closer. There is indeed a small sensor located in the >> bottom of the plastic coolant reservoir. If it comes on intermittently, >> then you are probably low on coolant and the solution is most likely to >> add a 50 mix to get you to the full cold line. >> >> It might also be a good time to flush and refill the system since this is >> supposed to be done every two years. If you do, then remove the coolant >> recovery reservoir and clean it thoroughly with hot soapy water. Make >> sure you also use the correct coolant (Saturn's use special coolant) and >> add the 2 crushed leak-stop pellets as well. The coolant and pellets are >> available from the dealer. >> >> Bob >> >> >> "Rob" > wrote in message >> ps.com... >>> Hello, >>> >>> I have a '96 Saturn with 120k on it. The coolant indicator light come >>> on and goes off intermittently. I had an OBD read and it reported a >>> problem stating something like "low coolant sensor". Is there a >>> sensor that monitors coolant level? If so, where is it--I don't see >>> anything in the overflow reservoir tub. This sensor obviously reports >>> back to the computer. Could this sensor error prevent the drive-cycle >>> from taking place. I disconnected my battery about 4 weeks/400mi ago >>> and my computer is reporting no codes which is preventing me from >>> getting an NYS (New York) inspection. >>> >>> By the way, the temp sensor is working fine and the car does not >>> overheat. >>> >>> Thank you for your help, >>> Rob >>> >> >> > > |
#6
|
|||
|
|||
low coolant
On Mar 12, 10:58 pm, "Bob Shuman" > wrote:
> It is dependent on the number of ignition (starts) cycles. I think it > requires 40 or 50 cycles to turn off/reset that history flag. > > - Show quoted text - I am not sure about the Saturn, but other GM cars requires the eng temp to raise more than 40° before it considers one ignition cycle completed. GM dealers have a proceedure to follow, to reset the history so it will pass inspections. James |
Thread Tools | |
Display Modes | |
|
|
Similar Threads | ||||
Thread | Thread Starter | Forum | Replies | Last Post |
Low coolant | joe_tide | BMW | 5 | November 29th 06 10:26 PM |
Coolant loss, bubbling coolant | [email protected] | Jeep | 13 | July 2nd 06 07:07 PM |
Coolant Smell : 2000 GT Rad, Coolant tank, or Intake. | Blix | Ford Mustang | 7 | December 1st 05 05:16 PM |
can I mix a type 2 Honda coolant with traditional green coolant? | [email protected] | Honda | 9 | October 17th 05 08:06 PM |
Coolant in the oil | maxpower | Technology | 4 | January 19th 05 07:18 PM |