If this is your first visit, be sure to check out the FAQ by clicking the link above. You may have to register before you can post: click the register link above to proceed. To start viewing messages, select the forum that you want to visit from the selection below. |
|
|
Thread Tools | Display Modes |
#1
|
|||
|
|||
Idle fluctuation, 99 Mazda Protege?
Hi Group,
I have an intermittent idle fluctuation more noticeable when cold. Some times the car stalls at a stop and when I put more loads on (lights, heater, etc) it gets even worse. Other times it will run just fine and then with no warning it will suddenly start running funny again. My tech. has not found any external vacuum leaks, he checked with spraying carb cleaner while it was acting up, no difference. So far we replaced the plugs and PCV valve, we did not change the idle adjustment since it runs fine at other times. We found no trouble codes. Coolant is full, no leaks. The only thing that made any difference was cleaning the throttle body of carbon. After that it did run great for about a week. Today we cleaned it again and it's running good for now. The car has 107K miles and other wise good power, no smoke, no oil consumption to speak of. The plugs looked like good tan color. Any ideas or suggestions are welcome and invited. Please Help! Thank you for reading, Karl. honda ruehs at cox dot net |
Ads |
#2
|
|||
|
|||
Make sure the flex duct from the MAF to the throttle body doesn't have a
slight crack or rip in one of the grooves. > wrote in message oups.com... > Hi Group, > > I have an intermittent idle fluctuation more noticeable when cold. Some > times the car stalls at a stop and when I put more loads on (lights, > heater, etc) it gets even worse. Other times it will run just fine and > then with no warning it will suddenly start running funny again. > > My tech. has not found any external vacuum leaks, he checked with > spraying carb cleaner while it was acting up, no difference. So far we > replaced the plugs and PCV valve, we did not change the idle adjustment > since it runs fine at other times. We found no trouble codes. Coolant > is full, no leaks. > > The only thing that made any difference was cleaning the throttle body > of carbon. After that it did run great for about a week. Today we > cleaned it again and it's running good for now. > > The car has 107K miles and other wise good power, no smoke, no oil > consumption to speak of. The plugs looked like good tan color. > > Any ideas or suggestions are welcome and invited. Please Help! > > Thank you for reading, > Karl. > honda ruehs at cox dot net > > ----== Posted via Newsfeeds.Com - Unlimited-Uncensored-Secure Usenet News==---- http://www.newsfeeds.com The #1 Newsgroup Service in the World! 120,000+ Newsgroups ----= East and West-Coast Server Farms - Total Privacy via Encryption =---- |
#3
|
|||
|
|||
Thanks Shep,
Yes the intake pipe/duct was thoroughly inspected when it was off to do the throttle body cleaning. It was visualy inspected while twisting and flexing, it got a clean bill of health. There is some sort of idle controll devise under the throttle body, I was thinking about removing this part to give good cleaning. Any one know what this part is actualy called (idle control solenoid? idle control motor? idle controll valve?) and if it is prone to sticking with high milage and possible internal carbon build up? When we finaly figure this thing out I will be sure to leave a follow up for future group history research purposes. Thanks, Karl. |
#4
|
|||
|
|||
pull it and clean the valve tip and shaft only, also the seat and passage in
the TB. > wrote in message oups.com... > Thanks Shep, > > Yes the intake pipe/duct was thoroughly inspected when it was off to do > the throttle body cleaning. It was visualy inspected while twisting and > flexing, it got a clean bill of health. > > There is some sort of idle controll devise under the throttle body, I > was thinking about removing this part to give good cleaning. Any one > know what this part is actualy called (idle control solenoid? idle > control motor? idle controll valve?) and if it is prone to sticking > with high milage and possible internal carbon build up? > > When we finaly figure this thing out I will be sure to leave a follow > up for future group history research purposes. > > Thanks, Karl. > > ----== Posted via Newsfeeds.Com - Unlimited-Uncensored-Secure Usenet News==---- http://www.newsfeeds.com The #1 Newsgroup Service in the World! 120,000+ Newsgroups ----= East and West-Coast Server Farms - Total Privacy via Encryption =---- |
Thread Tools | |
Display Modes | |
|
|
Similar Threads | ||||
Thread | Thread Starter | Forum | Replies | Last Post |
Mazda OEM Parts Catalogs for Sale | Joe | Mazda | 0 | February 12th 05 01:59 PM |
Cracked air intake hose - 1995 mazda protege lx | [email protected] | Technology | 0 | January 14th 05 07:49 PM |
'96 Civic Idle fluctuation when cold. | FartSmeller | Honda | 2 | October 16th 04 01:42 AM |
OEM Mazda parts microfiche sets for sale | Bigjfig | Mazda | 0 | August 29th 04 11:21 PM |