If this is your first visit, be sure to check out the FAQ by clicking the link above. You may have to register before you can post: click the register link above to proceed. To start viewing messages, select the forum that you want to visit from the selection below. |
|
|
Thread Tools | Display Modes |
#1
|
|||
|
|||
1995 Saturn SL1 hesitation, lurching
Car: 1995 Saturn SL1 SOHC, standard transmission, 4 cyl.
Mileage 237,000 Km Symptom: Hard to describe here but perhaps as “hesitation”? Either while running or at idle, engine seems to hesitate. More noticeable on the highway, pressing the gas pedal the car will on occasion jerk, lurch, sputter, or hesitate…. It is not continuous, but only very brief and at random. My thoughts: It does not appear to be the clutch slipping. It does engage well, I can slowly accelerate uphill engaging the clutch with no lurching at that point. I last changed the fuel filter at 142,754 Km (July 2004). The Haynes manual suggests the fuel filter be changed every 48,000Km, but I talked with a mechanic and he suggested every 100,000Km is OK, so I’m about near that. The fuel pump sounds OK, nothing particularly different than usual. I have used fuel injector and fuel system cleaners over the years, maybe 2-3 times per year. I also have used oil supplements, Bardahl B2, during the last 2 oil changes, (done every 5-6000 Km). I hear and feel the hesitation from the engine both at idle and when driving. The injector coils, cables and spark plugs are OK. I have had a failed coil before and recognize the power loss that occurs when this happens. This is not similar. I failed the emissions test in Dec 2008, and got the conditional pass. 2 tests failed for NO, revealing that the catalytic converter needed replacing, which I haven’t done yet. The O2 sensor was a little lean but was within spec. The exhaust seems to have no block from what I can observe, perhaps it’s partial. Suspension, steering, brakes are all OK. Any suggestions? Much Thanks in advance. Cheers, Roger |
Ads |
#2
|
|||
|
|||
1995 Saturn SL1 hesitation, lurching
NO failure on the emissions could also indict the EGR valve which are known
to fail at about 100K miles. You also do not say when the plugs and wires were last changed. These are easy to do and if not done recently could be the source of your hesitation. Lastly, from your comments, the fuel filter is overdue for replacement, and the air filter should also be changed every 12K miles too. Bob "Roger Ehrlich" > wrote in message ... > Car: 1995 Saturn SL1 SOHC, standard transmission, 4 cyl. > Mileage 237,000 Km > > Symptom: Hard to describe here but perhaps as “hesitation”? Either while > running or at idle, engine seems to hesitate. More noticeable on the > highway, pressing the gas pedal the car will on occasion jerk, lurch, > sputter, or hesitate…. It is not continuous, but only very brief and at > random. > > My thoughts: > It does not appear to be the clutch slipping. It does engage well, I can > slowly accelerate uphill engaging the clutch with no lurching at that > point. > > I last changed the fuel filter at 142,754 Km (July 2004). The Haynes > manual suggests the fuel filter be changed every 48,000Km, but I talked > with a mechanic and he suggested every 100,000Km is OK, so I’m about near > that. The fuel pump sounds OK, nothing particularly different than usual. > I have used fuel injector and fuel system cleaners over the years, maybe > 2-3 times per year. I also have used oil supplements, Bardahl B2, during > the last 2 oil changes, (done every 5-6000 Km). I hear and feel the > hesitation from the engine both at idle and when driving. > > The injector coils, cables and spark plugs are OK. I have had a failed > coil before and recognize the power loss that occurs when this happens. > This is not similar. > > I failed the emissions test in Dec 2008, and got the conditional pass. 2 > tests failed for NO, revealing that the catalytic converter needed > replacing, which I haven’t done yet. The O2 sensor was a little lean but > was within spec. The exhaust seems to have no block from what I can > observe, perhaps it’s partial. > > Suspension, steering, brakes are all OK. > > Any suggestions? > > Much Thanks in advance. > > Cheers, Roger |
#3
|
|||
|
|||
1995 Saturn SL1 hesitation, lurching
Thanks Bob
The EGR seems to be in good shape, I cleaned it back in Dec'08 and the spring is good. The plugs (RC14YC), wires and PCV valve, were also changed in Dec @ about 230,000Km. The air filter was changed in Aug'08 @ 223,000Km. I'll get the fuel filter changed. Cheers, Roger air filter was also changed in Dec Bob Shuman wrote: > NO failure on the emissions could also indict the EGR valve which are known > to fail at about 100K miles. You also do not say when the plugs and wires > were last changed. These are easy to do and if not done recently could be > the source of your hesitation. Lastly, from your comments, the fuel filter > is overdue for replacement, and the air filter should also be changed every > 12K miles too. > > Bob > > > > "Roger Ehrlich" > wrote in message > ... >> Car: 1995 Saturn SL1 SOHC, standard transmission, 4 cyl. >> Mileage 237,000 Km >> >> Symptom: Hard to describe here but perhaps as “hesitation”? Either while >> running or at idle, engine seems to hesitate. More noticeable on the >> highway, pressing the gas pedal the car will on occasion jerk, lurch, >> sputter, or hesitate…. It is not continuous, but only very brief and at >> random. >> >> My thoughts: >> It does not appear to be the clutch slipping. It does engage well, I can >> slowly accelerate uphill engaging the clutch with no lurching at that >> point. >> >> I last changed the fuel filter at 142,754 Km (July 2004). The Haynes >> manual suggests the fuel filter be changed every 48,000Km, but I talked >> with a mechanic and he suggested every 100,000Km is OK, so I’m about near >> that. The fuel pump sounds OK, nothing particularly different than usual. >> I have used fuel injector and fuel system cleaners over the years, maybe >> 2-3 times per year. I also have used oil supplements, Bardahl B2, during >> the last 2 oil changes, (done every 5-6000 Km). I hear and feel the >> hesitation from the engine both at idle and when driving. >> >> The injector coils, cables and spark plugs are OK. I have had a failed >> coil before and recognize the power loss that occurs when this happens. >> This is not similar. >> >> I failed the emissions test in Dec 2008, and got the conditional pass. 2 >> tests failed for NO, revealing that the catalytic converter needed >> replacing, which I haven’t done yet. The O2 sensor was a little lean but >> was within spec. The exhaust seems to have no block from what I can >> observe, perhaps it’s partial. >> >> Suspension, steering, brakes are all OK. >> >> Any suggestions? >> >> Much Thanks in advance. >> >> Cheers, Roger > > |
#4
|
|||
|
|||
1995 Saturn SL1 hesitation, lurching
On Apr 19, 1:12*pm, Roger Ehrlich > wrote:
> Car: 1995 Saturn SL1 SOHC, standard transmission, 4 cyl. > Mileage 237,000 Km > > Symptom: Hard to describe here but perhaps as “hesitation”? Either while > running or at idle, engine seems to hesitate. More noticeable on the > highway, pressing the gas pedal the car will on occasion jerk, lurch, > sputter, or hesitate…. It is not continuous, but only very brief and at > random. > > My thoughts: > It does not appear to be the clutch slipping. It does engage well, I can > slowly accelerate uphill engaging the clutch with no lurching at that point. |
#5
|
|||
|
|||
1995 Saturn SL1 hesitation, lurching
Thanks Scott
Will do, since my CAT needs replacing anyway before the next emissions test I'll get it replaced. .... looked up the Walker CAT on http://www.walkerexhaust.com/catalog...uponScreen.asp May as well get the fuel filter changed too. If that gets clogged the engine is starved of petrol. I do not seem to be at the severe point yet were there is a strain on the fuel pump. I've heard that before back in 2004, which was resolved by a fuel filter change. I replaced my EGR before in 2004 too. The symptoms then were stalling when decelerating the car down to a stop. I'm not experiencing that. Cheers, Roger Scott wrote: > On Apr 19, 1:12 pm, Roger Ehrlich > wrote: >> Car: 1995 Saturn SL1 SOHC, standard transmission, 4 cyl. >> Mileage 237,000 Km >> >> Symptom: Hard to describe here but perhaps as “hesitation”? Either while >> running or at idle, engine seems to hesitate. More noticeable on the >> highway, pressing the gas pedal the car will on occasion jerk, lurch, >> sputter, or hesitate…. It is not continuous, but only very brief and at >> random. >> >> My thoughts: >> It does not appear to be the clutch slipping. It does engage well, I can >> slowly accelerate uphill engaging the clutch with no lurching at that point. >> >> I last changed the fuel filter at 142,754 Km (July 2004). The Haynes >> manual suggests the fuel filter be changed every 48,000Km, but I talked >> with a mechanic and he suggested every 100,000Km is OK, so I’m about >> near that. The fuel pump sounds OK, nothing particularly different than >> usual. I have used fuel injector and fuel system cleaners over the >> years, maybe 2-3 times per year. I also have used oil supplements, >> Bardahl B2, during the last 2 oil changes, (done every 5-6000 Km). I >> hear and feel the hesitation from the engine both at idle and when driving. >> >> The injector coils, cables and spark plugs are OK. I have had a failed >> coil before and recognize the power loss that occurs when this happens. >> This is not similar. >> > My vote is for the CAT. > I replaced mine at 165,000 Miles on my '95 SW1. Same symptoms, and > that loud coffee can full of rocks noise on accel. > If you do go this route buy a DIRECT FIT that comes with the pipe that > bolts onto the exhaust manifold. It will save mucho time and > frustration. Check Rock Auto for the "Walker" brand. > > Scott > >> I failed the emissions test in Dec 2008, and got the conditional pass. 2 >> tests failed for NO, revealing that the catalytic converter needed >> replacing, which I haven’t done yet. The O2 sensor was a little lean but >> was within spec. The exhaust seems to have no block from what I can >> observe, perhaps it’s partial. >> >> Suspension, steering, brakes are all OK. >> >> Any suggestions? >> >> Much Thanks in advance. >> >> Cheers, Roger > |
#6
|
|||
|
|||
1995 Saturn SL1 hesitation, lurching
Clean up the throttle body while you are doing the other work. A dirty TB
usually results in an erratic or misfire during idle, but not during acceleration. Bob .. "Roger Ehrlich" > wrote in message ... > Thanks Scott > Will do, since my CAT needs replacing anyway before the next emissions > test I'll get it replaced. .... looked up the Walker CAT on > http://www.walkerexhaust.com/catalog...uponScreen.asp > > May as well get the fuel filter changed too. If that gets clogged the > engine is starved of petrol. I do not seem to be at the severe point yet > were there is a strain on the fuel pump. I've heard that before back in > 2004, which was resolved by a fuel filter change. > > I replaced my EGR before in 2004 too. The symptoms then were stalling when > decelerating the car down to a stop. I'm not experiencing that. > |
#7
|
|||
|
|||
1995 Saturn SL1 hesitation, lurching
Resolution & Cause:
Bob suggested also the spark plug cables….. I regularly check & replace the plugs & cables…. Cables in Fall’07, plugs in Dec’08. Spark plug cable for cylinder #3 was momentary open circuit, thus sporadic misfires; damaged connector broke off burning at connector to spark plug. Resistances of both the ignition coils and other cables were in spec. I’ve had open circuit problems with the spark plug cable for cylinder #3 (the short cable) twice before (brand Niehoff). Thus cable replaced. I also cleaned the throttle body, it was in good condition and I do this regularly. I also examined and cleaned the EGR valve again, some carbon (expected) but the spring was in good shape. Car runs fine now. I’ll change the CAT & fuel filer in the near future. Thanks & Cheers, Roger Bob Shuman wrote: > Clean up the throttle body while you are doing the other work. A dirty TB > usually results in an erratic or misfire during idle, but not during > acceleration. > > Bob > . > "Roger Ehrlich" > wrote in message > ... >> Thanks Scott >> Will do, since my CAT needs replacing anyway before the next emissions >> test I'll get it replaced. .... looked up the Walker CAT on >> http://www.walkerexhaust.com/catalog...uponScreen.asp >> >> May as well get the fuel filter changed too. If that gets clogged the >> engine is starved of petrol. I do not seem to be at the severe point yet >> were there is a strain on the fuel pump. I've heard that before back in >> 2004, which was resolved by a fuel filter change. >> >> I replaced my EGR before in 2004 too. The symptoms then were stalling when >> decelerating the car down to a stop. I'm not experiencing that. >> > > |
#8
|
|||
|
|||
1995 Saturn SL1 hesitation, lurching
Great! Glad to hear that you could keep that 14 year old vehicle running
.... As I recall, yours is pretty low mileage so as long as you don't live in the rust belt, you should be able to keep it going a few more years! Just keep the oil full and the engine should keep on going. Bob .. "Roger Ehrlich" > wrote in message ... > Resolution & Cause: > Bob suggested also the spark plug cables….. > > I regularly check & replace the plugs & cables…. Cables in Fall’07, plugs > in Dec’08. > > Spark plug cable for cylinder #3 was momentary open circuit, thus sporadic > misfires; damaged connector broke off burning at connector to spark plug. > Resistances of both the ignition coils and other cables were in spec. I’ve > had open circuit problems with the spark plug cable for cylinder #3 (the > short cable) twice before (brand Niehoff). Thus cable replaced. > > I also cleaned the throttle body, it was in good condition and I do this > regularly. I also examined and cleaned the EGR valve again, some carbon > (expected) but the spring was in good shape. > > Car runs fine now. > > I’ll change the CAT & fuel filer in the near future. > > Thanks & Cheers, Roger > |
#9
|
|||
|
|||
1995 Saturn SL1 hesitation, lurching
Actually my mileage is quite high..... > 237,000 Km .... and I live in
the great rust belt of Canada..... our Saturns have the plastic body panels though.... I occasional get some rust on the door rocker panels.... but treat everything with rust inhibitors. Just to elaborate folks.... Sorry but the symptom was hard to describe. It was not really a continuous hesitation.... I've had that before when a coil or spark cable fails outright... I had good power and acceleration.... there was a random lurch like the car was losing power for less then a second then would continue.... It was the Spark plug cable for cylinder #3 that was momentary open circuit.... it was failing... I could see the burn mark at the failed electrical connection point in the cable as when I removed it to test the plug connector broke off and was stuck on the spark plug..... I could see the burn mark on it too. Just to help other folks with the library of knowledge for auto troubleshooting. Take care folks. Cheers, Roger Bob Shuman wrote: > Great! Glad to hear that you could keep that 14 year old vehicle running > ... As I recall, yours is pretty low mileage so as long as you don't live > in the rust belt, you should be able to keep it going a few more years! > Just keep the oil full and the engine should keep on going. > > Bob > . > "Roger Ehrlich" > wrote in message > ... >> Resolution & Cause: >> Bob suggested also the spark plug cables….. >> >> I regularly check & replace the plugs & cables…. Cables in Fall’07, plugs >> in Dec’08. >> >> Spark plug cable for cylinder #3 was momentary open circuit, thus sporadic >> misfires; damaged connector broke off burning at connector to spark plug. >> Resistances of both the ignition coils and other cables were in spec. I’ve >> had open circuit problems with the spark plug cable for cylinder #3 (the >> short cable) twice before (brand Niehoff). Thus cable replaced. >> >> I also cleaned the throttle body, it was in good condition and I do this >> regularly. I also examined and cleaned the EGR valve again, some carbon >> (expected) but the spring was in good shape. >> >> Car runs fine now. >> >> I’ll change the CAT & fuel filer in the near future. >> >> Thanks & Cheers, Roger >> > > > |
#10
|
|||
|
|||
1995 Saturn SL1 hesitation, lurching
On Apr 19, 10:21*pm, Roger Ehrlich > wrote:
> Thanks Bob > > The EGR seems to be in good shape, I cleaned it back in Dec'08 and the > spring is good. The plugs (RC14YC), wires and PCV valve, were also > changed in Dec @ about 230,000Km. The air filter was changed in Aug'08 @ > 223,000Km. I'll get the fuel filter changed. > Where is the EGR valve on the SL1? The EGR valve on my '93 SL2 is clearly visible, but I have no idea where it is on my '96 SL1. |
Thread Tools | |
Display Modes | |
|
|
Similar Threads | ||||
Thread | Thread Starter | Forum | Replies | Last Post |
Hesitation while accelerating Saturn SL1 | Roger Ehrlich - Alumni-2004 | Saturn | 15 | June 3rd 16 02:18 PM |
1995 saturn | mrjeckellmrhide | Saturn | 0 | November 27th 06 02:51 AM |
1995 saturn | emancae | Saturn | 9 | November 1st 06 08:34 PM |
1995 ram 3.9L hesitation | scott and barb | Technology | 2 | April 27th 05 05:41 PM |
1995 Saturn SL2 | ysone | Saturn | 8 | October 21st 04 02:40 AM |